Wind. Blows: A Special Edition Of The Board Chronicles   2 comments

The Board Chronicles is an ongoing series of articles about the adventures of Mrs M’s Handmade as a vendor at community festivals & craft fairs. Mrs M’s subsidiary, Mr M’s Woodshop, has been approved to create this chronicle for the good of vendorkind.

It was time to up our game.

Mrs M’s Handmade is now entering our 5th year of vendorhood. We started oh-so-humbly … and we’re still learning at every event. Unfortunately.

This year, we want to expand what we do. It’s our intention to do some bigger shows … and we scheduled ourselves for our first out-of-state event, Winterfest in Lake Havasu, AZ. That event is 300 miles from home, which is almost as far for us to travel as the events we’ve done in the bay area.

California’s a big state, you see. Going to Arizona from LA is closer. But, I digress.

We went to Arizona to go a-vendoring. What could go wrong?

Quoth The Fifth Element, Leeloo, “Wind blows ….”

This is the story of what happened while we slept.

Saturday was what we expected, really, only less. This very large vendor event has a Saturday morning setup, and we were there at 5:15am to line up for the 6am beginning of the process. We did what we do, and set up our booths, # 358 & 360, in the middle of McCulloch Blvd. We were ready for the crowds at 9am. People were there, which was great … but they didn’t buy much, unfortunately. Our vendor friends universally reported sales that were down significantly from last year. We ended Saturday at 5pm with a very, very disappointing sales total and complete exhaustion. We buttoned up the booths, put a table cloth over the soaps, and went to the motel to lick our wounds.

We knew that there was a windstorm forecast to hit at about 11pm, but we didn’t really worry about it. After all, we knew that we were prepared. Our weights were in place, our new Undercover canopies have thick, heavy side walls … we were ready.

We thought.

We were wrong.

We arrived before 8am on Sunday, because I wanted to tweak my display a bit. That’s what I would end up doing, but nothing else went according to plan.

Here’s the first thing I saw when we walked up to the booth:

My first look at the wind damage. No big deal, right?

This is a picture of the back corner of “my” booth (we do a double booth, so Mrs M has her side, and I have my side). See the upended table? That’s the back of my neighbor’s booth. My booth’s walls are what you see on the left side of the photo, and you’ll see that my canopy has shifted forward 3′. The booth did not go airborne, due to the weights that we had in place. However, the wind did push the sail formed by the wall of the booth forward, relentlessly, in spite of the weight. When the canopy was pushed and slid across the asphalt, the wall eventually rode up and over the top of the table. That, in turn, resulted in the boards I had stupidly left on the table getting knocked down. Only 3 pieces hit the pavement. Luckily.

Note that our weight is velcroed in place at the bottom of the canopy leg, just as it’s supposed to be. My neighbor’s booth is also secured, with the orange ratchet strap attached to the roof strut and holding a sandbag. Their booth (no walls) did not move, and did not protect my booth from the wind.

At this point, though, I was relieved. I had already seen canopies that were upended and destroyed in the wind, so I knew we were lucky that it was not worse. It took me a couple of thoughts to realize that the front of the booth – which looked perfect – was not all there. 10′ of our booth was missing. That’s when my focus shifted, and I saw this.

Velda’s booth, crushed by a flying canopy.

Here you see the opposite corner of my booth from the previous picture, and it was the front, center of our double booth. All you can see of Mrs M’s booth is the crumpled wall that’s on the pavement, and the leg and roof struts that have been folded parallel … they are no longer perpendicular. Mrs M’s Booth should be about 9′ tall; now it’s smashed.

Time slowed down. I surveyed the damage and realized that our day had just taken a very significant left turn.

Bad words may have been spoken at this point.

The booth behind Velda and her neighbor (a real estate agent) was a 10’x20′ booth selling dry soup mixes & such. The soup people had 2x 10′ canopies. They had bungeed the roofs together, and then secured the canopies with ratchet straps and DIY weights made from 4″ PVC pipe and, uh, stuff.

More on that later.

During the night, the wind lifted the dry soup canopies up, and then they flipped over and crushed Mrs M’s canopy, as well as that of her neighbor. Both Mrs M’s and the real estate agent’s canopies were properly weighted down and did not move from their spots. They did, however, get crushed by the Flying Dry Soup Canopy.

The Flying Dry Soup Canopy

This is the view from the far side of the real estate booth. That booth had a cheap EZ Up canopy … crushed flat. Note the 2 front center poles of the Flying Dry Soup Canopy: no weights are attached. These poles would have been front & center in the dry soup display, so the vendor did not put unsightly weights there.

Mistake. Big Mistake.

A DIY weight that really isn’t.

This is a picture of one of the weights that didn’t hold down the Flying Dry Soup Canopy. 2 things are wrong here:

  1. The weight itself is not properly secured. The weight should be connected to the ratchet strap through the eye hole mounted on the weight (now facing the pavement). Also, the weight must be secured to the leg itself. Otherwise, the wind will blow, the tent will shake … the weight will start swinging free of the leg, and then the pendulum effect will increase the power of the wind and speed the catastrophic failure of the canopy. As it did in this case!
  2. The weight itself is about 30″ tall. I have made weights somewhat similar to these. When I made my versions, I filled the 4″ PVC with concrete and rock. My DIY PVC weights did weigh 35 pounds when I put them on our bathroom scale. The pictured “weight,” however, was lifted by Velda using one arthritic finger. I estimate it was no more than 20 pounds; she believes it was under 10 pounds. I can guarantee it was not 50 pounds.

What’s important about 50 pounds? Here’s the relevant rule, which was a part of the event application signed by every vendor:

All vendors must have weights for any canopies in use. All four corners must have weights of at least 50lbs attached.

So, if you have 2x 10′ canopies side by side, you actually have 8 corners. When you put 50 pounds on each corner, you need 400 pounds of weight attached. In my opinion, the Flying Dry Soup Canopy did not have half of that.

The back of the Flying Dry Soup Canopy, now upside down and sitting in the middle of Mrs M’s booth. One weight is on the near corner; you can see the orange ratchet strap holding another on the far corner. But the back, middle?

So, we know there’s devastation here. Nothing to do but clean it up. With all of the involved vendors eventually helping, we took apart the offending canopies, untying the bungees and disconnecting the weights. Mrs M’s canopy could then be removed, to finally reveal the remains of her booth:

The top layers of Mrs M’s purpose built display did get pushed onto the ground, but the bottom layer was left alone. Under the tablecloth is the soap, which was totally undamaged. But as the asphalt underneath was revealed….

Amazingly, none of the wooden pieces were broken. Over 100 lotion bars were destroyed, as well as a small number of lotions and a single beard oil.

The saddest thing I saw broken:

So, nothing to do but get to it. Mrs M started cleaning up, and I started picking up.

Clean up, well in hand. 10am.

We cleaned up Mrs M’s booth entirely, and then decided that we should keep my booth open for the day. All of our costs were sunk; her stuff was safe. We would gain nothing by leaving for home, and if we stayed we just might sell a board or two.

That’s the story for the next installment of The Board Chronicles.

Still unknown is what will happen to our financial losses caused by the Flying Dry Soup Canopy. We do have their insurance information, and do expect to be compensated for the losses that we incurred. Will that happen? No clue.

Want to read about an even worse event weekend? The link’s below, When Nature Fights Back….

We expanded “my” booth into Mrs M’s booth space when we finally tweaked my display. There’s still cleanup needed, however.

More

When Nature Fights Back: A Special Edition Of The Board Chronicles

 

 

2 responses to “Wind. Blows: A Special Edition Of The Board Chronicles

Subscribe to comments with RSS.

  1. Oh my! You all have a wonderful attitude about the mishap. Hope things improve for you.

  2. Pingback: The Board Chronicles: Lake Havasu Winter fest 2018 | MowryJournal.com

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out / Change )

Twitter picture

You are commenting using your Twitter account. Log Out / Change )

Facebook photo

You are commenting using your Facebook account. Log Out / Change )

Google+ photo

You are commenting using your Google+ account. Log Out / Change )

Connecting to %s

%d bloggers like this: